Kia Rio: Tailgate / Tailgate Latch

Kia Rio 2017-2025 YB Service Manual / Body (Interior and Exterior) / Tailgate / Tailgate Latch

Components and components location

Component Location

(5Door)

1. Tailgate Latch

Repair procedures

Replacement

(5Door)

Put on gloves to protect your hands.

•	Use a plastic panel removal tool to remove interior trim pieces without marring the surface.

•	Take care not to bend or scratch the trim and panels.

1.	Remove the Tailgate trim. (Refer to Tailgate - "Tailgate Trim")

2.	Disconnect the Tailgate latch connector (A).

Remove the Tailgate latch assembly (B) after loosening the mounting bolts (A).

Tightening torque :

6.9 - 10.8 N·m (0.7 - 1.1 kgf·m, 5.1 - 8.0 lb·ft)

Install in the reverse order of removal.

•	Make sure the Tailgate locks/unlocks and opens/closes properly.

•	Adjust the Tailgate alignment.

•	Make sure the connectors are connected in properly.

Tailgate Trim

Components and components location Component Location 1. Tailgate trim Repair procedures Replacement &nb ...

Tailgate Lift

Repair procedures Replacement (5Door) Be careful as the tailgate may fall down on people when the lifts ...

Other information:

Kia Rio 2017-2025 YB Service Manual: Cluster Ionizer (FATC only)

Description and operation Description The cluster ionizer helps to clean up odors in the vehicle or from the air-conditioner system. When the ignition switch ON, the inoizer runs a "CLEAN" mode and then a "ION" mode, switching every about 15 minutes. In the ...

Kia Rio 2017-2025 YB Owners Manual: Rear turn signal lamp bulb replacement (for 4 door)

1. Open the trunk lid. 2. Remove the service cover by pulling out the service cover. 3. Remove the socket from the assembly by turning the socket counterclockwise until the tabs on the socket align with the slots on the assembly. 4. Remove the bulb from the socket by pressing it in and rota ...